Car Audio Setup for SANTRO XING

rsjaurr · 20th April 2006, 21:14

Quote:

Originally Posted by gunbir

Hmm... playing at high volumes for long... reminds me of the Auto Expo when we had all our amps playing at full output non-stop 10-12 hours everyday. The Audison LRx1.400 powering the Mille 21" was putting out 900w into 1ohm...all day long... it got warm but never shut down.

Gunbir...my amp do shut down sometime.I have told u guys this probelm before.As advised by JB,i did check if the spk cables is leaking and toucjing some metal part of car.I couldn't find any leak but i did replaced all spk cables.

But while coming from JLD,only once my amp shut down when i raided vol to around 28 after abt 45 min.I had to lower the volume then.
Lately i have been very busy but i will cover the visible spk cables with cable cover/sleeve and see if it happens again.

And gunbir i am yet to put mdf borad between amp and rar seat.
JK...its must for amp's rear seat installation o/w amp's screws would keep coming out.[happening to me]
And why dont u go for audison RCA cables?

gunbir · 20th April 2006, 21:55

Quote:

Originally Posted by rsjaurr

Gunbir...my amp do shut down sometime.I have told u guys this probelm before.As advised by JB,i did check if the spk cables is leaking and toucjing some metal part of car.I couldn't find any leak but i did replaced all spk cables.

RSJ... It just might be the 2ohm Infinity speakers are a bit much for the amp which would be a bit strange. Its also possible you got a B-stock amp.

jkdas · 20th April 2006, 21:57

Quote:

Originally Posted by rsjaurr

JK...its must for amp's rear seat installation o/w amp's screws would keep coming out.[happening to me]
And why dont u go for audison RCA cables?

o/w? YOu did it that way Gunbir said? I have to do it sometime next week. I need RCA before that. Also, I may change my HU too.

I am trying for it (Audison). I have asked a friend to check for it at Hyd. Any idea how much it would cost? maybe I will pm Gunbir to send it to me via courier if I cant find it here or at Hyd .

And can someone find that thread about these cables? I am sure that Gunbir had a thread abt this.

jkdas · 20th April 2006, 23:30

The contact was made.

I am going for Audison FT2600 RCA x 2nos. NOw I have to sort out about the Power cables with fuse too. Maybe I will get Audison one for that too.

jkdas · 22nd April 2006, 22:55

Think I will keep the Pio amp at the old place but with some padding and 4 screws. It looks sturdy enough for it. The behind the seat work will have to be tried by myself later on. I doubt if anyone from Tvm could do a nice job abt it.

The Audison RCA's I should be going in for, FT2600@760Rs per pair

So RCA time next week. Whers my damn salary, boss?

rsjaurr · 23rd April 2006, 13:23

Quote:

Originally Posted by gunbir

RSJ... It just might be the 2ohm Infinity speakers are a bit much for the amp which would be a bit strange. Its also possible you got a B-stock amp.

Yeah.........thats what i have been saying before.That amp is powering 4 infinty spk @2ohm +2 tweeters and a SQ subw in sealed box.

Probably its bit too much for amp.

But plz dont break my heart by saying its from B stock.

jkdas · 23rd April 2006, 15:51

Alright; whats a B stock thing

gunbir · 23rd April 2006, 16:10

Quote:

Originally Posted by jkdas

Alright; whats a B stock thing

Most companies that outsource their manufacturing to China, Korea etc sometimes dont do effective quality control before shipping from the factory. The sometimes prefer to do the QC after the consignments land in say... USA. Some stocks fail QC. Now since they have already been manufactured, transported and imported, it doesnt make sense to send them back to China. So they are sold on consignment basis. Thats how unauthorised online websites get their stocks. Unfortunately, a lot of these stocks also make their way to our shores and get sold in the grey market.

rsjaurr · 24th April 2006, 16:17

Quote:

Originally Posted by gunbir

Most companies that outsource their manufacturing to China, Korea etc sometimes dont do effective quality control before shipping from the factory. The sometimes prefer to do the QC after the consignments land in say... USA. Some stocks fail QC. Now since they have already been manufactured, transported and imported, it doesnt make sense to send them back to China. So they are sold on consignment basis. Thats how unauthorised online websites get their stocks. Unfortunately, a lot of these stocks also make their way to our shores and get sold in the grey market.

Just to add to Gunbir's post,they call it 2nd stock in USA if any item fails QC checks.Sometime these items can be repaired and sold as refurbished items.
Thankfully my all items were not refurbished or from 2nd stock.I did confirm that.And my amp is made in south korea and not china.

Anyway i will be free after my wife joins her new job in next few dyas and will try to find the cause of amp shutting down occasionally.

I plan to cover the entire spk wiring with some sleeve to prevent any any leaked spk wiring touching any metal part of car,use sandpaper for ground connection as my installer dint use it before.[to me this may be the cause].Actually i cant get that HU sleeve/frame which gunbir/JB advised to use for HU install.When i get it,i will reopen the whole setup and try to find the reason.

Sam Kapasi · 25th April 2006, 00:09

Quote:

Originally Posted by gunbir

Most companies that outsource their manufacturing to China, Korea etc sometimes dont do effective quality control before shipping from the factory. The sometimes prefer to do the QC after the consignments land in say... USA. Some stocks fail QC. Now since they have already been manufactured, transported and imported, it doesnt make sense to send them back to China. So they are sold on consignment basis. Thats how unauthorised online websites get their stocks. Unfortunately, a lot of these stocks also make their way to our shores and get sold in the grey market.

Therefore, buy all original products with Bill and warranty. Don't take a chance with the grey market. Aids ka khatra hain. The End.

navin · 25th April 2006, 09:54

right said Sam, see http://www.team-bhp.com/forum/car-en...car-audio.html

dmitri · 25th April 2006, 10:41

jkdas, Do you have pics of the Remote of PA275??

Quote:

Originally Posted by jkdas

The little guy!

http://www.team-bhp.com/forum/191321-post311.html

more pix later

jkdas · 25th April 2006, 21:07

dmitri; I will post it tomorrow

And guys see that keychain? Anyone can get me atleast one of those? They are in bloody demand here:(

Sam Kapasi · 25th April 2006, 22:08

Quote:

Originally Posted by jkdas

dmitri; I will post it tomorrow

And guys see that keychain? Anyone can get me atleast one of those? They are in bloody demand here:(

LOL i dont think any of the guys anywhere can get you that. Those are super limited edition. However a few selected (read very few) TBHP members will have one each. Maybe someone would send you his. (Ask navin or rudra heh heh)

navin · 26th April 2006, 09:22

Quote:

Originally Posted by Sam Kapasi

Those are super limited edition. Maybe someone would send you his. (Ask navin or rudra heh heh)

You want to take a keychain from my 4 year old son! I wont dare to. You are however welcome to try. Just get good ear muffs.

20th April 2006, 23:30	#409
jkdas Senior - BHPian Join Date: Sep 2005 Location: Thiruvananthapu Posts: 9,685 Thanked: 1,497 Times View My Garage	The contact was made. I am going for Audison FT2600 RCA x 2nos. NOw I have to sort out about the Power cables with fuse too. Maybe I will get Audison one for that too. Last edited by jkdas : 20th April 2006 at 23:31.
	() Thanks

22nd April 2006, 22:55	#410
jkdas Senior - BHPian Join Date: Sep 2005 Location: Thiruvananthapu Posts: 9,685 Thanked: 1,497 Times View My Garage	Think I will keep the Pio amp at the old place but with some padding and 4 screws. It looks sturdy enough for it. The behind the seat work will have to be tried by myself later on. I doubt if anyone from Tvm could do a nice job abt it. The Audison RCA's I should be going in for, FT2600@760Rs per pair So RCA time next week. Whers my damn salary, boss? Last edited by jkdas : 22nd April 2006 at 23:14.
	() Thanks

23rd April 2006, 15:51	#412
jkdas Senior - BHPian Join Date: Sep 2005 Location: Thiruvananthapu Posts: 9,685 Thanked: 1,497 Times View My Garage	Alright; whats a B stock thing
	() Thanks

25th April 2006, 09:54	#416
navin Team-BHP Support Join Date: Mar 2004 Location: Mumbai Posts: 25,421 Thanked: 9,998 Times	right said Sam, see http://www.team-bhp.com/forum/car-en...car-audio.html
	() Thanks

25th April 2006, 21:07	#418
jkdas Senior - BHPian Join Date: Sep 2005 Location: Thiruvananthapu Posts: 9,685 Thanked: 1,497 Times View My Garage	dmitri; I will post it tomorrow And guys see that keychain? Anyone can get me atleast one of those? They are in bloody demand here:( Last edited by jkdas : 25th April 2006 at 21:09.
	() Thanks